By Eddy − On Sunday, April 2, 2017, 7 years ago in Pork Recipes
4 out of 5 with 159 ratings
comments: 2 - views: 131504

Portuguese Chouriço Recipe

Portuguese Chouriço Recipe

This is a delicious and traditional Portuguese chouriço recipe.

Preparation timen/a
Cooking Timen/a
Ready In10 h 55 min
Level of DifficultyModerate
Servings12

Ingredients

16 lbs of trimmed and cubed pork butt1/2 cup of garlic cloves, cut in half1/2 cup of salt1 and 1/2 liters of red wine, more if needed100 grams of mild paprika10 grams of black pepper10 grams of ground red hot pepper4 bay leaves15 to 20 hog casings (depending on size)
16 lbs of trimmed and cubed pork butt1/2 cup of garlic cloves, cut in half1/2 cup of salt1 and 1/2 liters of red wine, more if needed100 grams of mild paprika10 grams of black pepper10 grams of ground red hot pepper4 bay leaves15 to 20 hog casings (depending on size)
Get Portuguese ingredients

Directions

  1. Start by trimming most of the fat off the pork.
  2. Cut pork into cubes, about 2 inch diameter.
  3. Place all the cubed pork, seasonings and wine in a large basin (try not to break down the bay leaves because they will have to be removed before filling the casting).
  4. Mix everything together making sure all the seasoning is evenly throughout the pork.
  5. Cover well with a plastic bag and place meat in fridge (mix every 12 hours for 2 days).
  6. At every mixing, cook a little bit of the pork to taste if any more seasoning is needed (remember when smoking, the pork will lose a lot of flavor).
  7. On filling day, rinse each casting a few times, check for hole or defects.
  8. Using baking twine, tie off one end of the casting.
  9. Remove all the garlic cloves and bay leaves before filling.
  10. Place the open end of the casting on the funnel. while holding the casting onto the funnel, begin to fill the casings with the pork, slowly working the meat to the end of the casting (use a safety pin to pop any air pockets)., once filled, tie the other end.
  11. Hang the filled sausages on a stick or similar without touching, place in the smoker and start your fire.
  12. Be careful that the flames do not reach the sausage (remember, low heat for a long period of time).
  13. Keep any eye on the fire for flare ups or if fire goes out.
  14. After 24 hours, let the fire go out, flip the sausages, then start the firing process over again (at this point when you flip them, you will need to determine if you are halfway done or if it will take longer than an additional 24 hours), this is tricky, and where experience comes into to play, smoking for 24 hours on each side is usually the minimum, (an additional day or two may be needed).
  15. When the sausages are done, place them indoors and let them dry.

**Place some sort of gate in front of pit opening, so if the fire goes out, animals will come and eat all the hard work you have just put in to it.

Adapted from a: homemadeinterest.com Recipe
Photo Credit: Dennis Wilkinson, flickr.com

You might also like:

Portuguese Chouriço Kebabs Recipe
Portuguese Chouriço Kebabs Recipe

Portuguese chouriço kebabs are a popular dish in Portugal and other Portuguese-speaking countries.

Level of DifficultyVery Easy
Servings4
Portuguese Pork Stew Recipe
Portuguese Pork Stew Recipe

This Portuguese pork stew with cockles and spicy red pepper sauce recipe is delicious.

Level of DifficultyModerate
Servings6
Paula's Portuguese Chouriço à Bras Recipe
Paula's Portuguese Chouriço à Bras Recipe

How to make Portuguese chouriço à bras.

Level of DifficultyEasy
Servings4

Doug Hart
Doug Hart
16 lbs of pork butt yield only 12 servings? I think we have a math problem!
6 months ago, Wednesday, September 13, 2023
reply
Eddy
I can only choose up to 12 servings, I get it, it's not even close, but it is what it is.
6 months ago, Thursday, September 14, 2023
captcha

You might also like:

Lina's traditional Portuguese bread is crispy on the outside and soft on the inside, it is great with butter and cheese and a good cup of coffee.
How to make Portuguese sonhos, a  delightful pastry, which translate to dreams in English, are a popular dessert often enjoyed during festive occasions or simply as a comforting indulgence.
Trying the local and most authentic foods when you travel should always be a top priority! It's one of the best ways to experience local culture. Today, I got to try the very best local cuisine Madeira has to offer.
If you are travelling to Madeira Island, you have to watch this amazing Madeira food tour.
Thanksgiving Day, annual national holiday in the United States and Canada celebrating the harvest and other blessings of the past year. 
I wanted to take you along with me today to this amazing beach that's only 20 minutes away from Lisbon.